An Experimental Study on Quarry Dust as Partial Replacement for Sand in Concrete

Bodapati Sandhya Rani; L Rama Prasad Reddy; S Reddemma; Ch. Dinesh Chandra; A Ranganathan

doi:10.55524/ijircst.2020.8.6.18

Abstract

Concrete plays the key role and a large quantum of concrete is being utilized in every construction practices. Quarry Dust which is a other non-voluble waste material after the extraction and processing of rocks to form fine particles less than 4.75mm.The Quarry dust can be an alternative to the river sand since river sand is expensive due to excessive cost of transportation from natural sources and also large scale depletion of these sources creates environmental problems .In this project work the usage of different quarry dusts by studying the physical and chemical properties, workability of the quarry dust concrete, with different ratios of 0%, 20%, 30%&40% for M20 grade of concrete behavior of quarry dust reinforced cement concrete beams, Sieve analysis was conducted for quarry dust and sand. Mix design has been developed using IS Mix Design for various proportion of four different quarry dust with river sand. Tests were conducted on cubes and cylinders to study the compressive and tensile strengths of concrete made of various proportion of quarry dust with river sand, optimum strength test values of various proportion of different quarry dust with river sand and the results were compared with natural sand.

Keywords

River Sand, Quarry dust, workability, compressive strength, tensile strength.

References

IS 2386-1963 (Part I to VIII) “Indian standard Methods of test for Aggregate for Concrete” Bureau of Indian standards, New Delhi.
IS 383-1970, “Specification for coarse and fine aggregates from natural sources for concrete” Bureau of Indian standards, New Delhi.
IS 516-1959, “Indian Standard Methods of Test for Strength of Concrete” Bureau of Indian Standards, New Delhi.
Nagaraj, T.S. and Zahinda Banu, 1996. “Efficient Utilization of Rock Dust and Pebbles as Aggregates in Portland Cement Concrete” The Indian Concrete Journal, pp: 53-56.
Nagaraj, T.S., 2000. “Proportioning Concrete Mix with Rock Dust as Fine Aggregate” CE and CR Journal., pp: 27-31
Narasimhan, C., B.T. Patil and H. Sankar Sanni, 1999. “Performance of Concrete with Quarry Dust as Fine Aggregate-An Experimental Study”. CE and CR Journal, pp: 53-56.
Nataraja, M.C., T.S. Nagaraj and A. Reddy, 2001. “Proportioning Concrete Mix with Quarry Wastes Cement,” Concrete and Aggregate Journal, pp: 81-87.
Nisnevich, M., G. Sirotin and Y. Eshel, 2003. “Light weight concrete containing thermal power station and stone quarry waste”. Magazine of Concrete Research, pp: 313-320
Babu, K.K., R. Radhakrishnan and E.K.K. Nambiar, 1997. “Compressive Strength of Brick Masonry with Alternative - Aggregate Mortar”. CE and CR Journal, pp: 25-29.

Cites this article as

B. S. R. , L. R. P. R. , S. R. , C. D. C. , A. Ranganathan, "An Experimental Study on Quarry Dust as Partial Replacement for Sand in Concrete", International Journal of Innovative Research in Computer Science and Technology (IJIRCST), Vol-8, no.6, pp.459-465, 2020. Available from: https://doi.org/10.55524/ijircst.2020.8.6.18

Corresponding Author

Bodapati Sandhya Rani

Assistant Professor, Department of Civil Engineering, PACE Institute of Technology & Sciences, Ongole, India

Download Full Paper

Download PDF

No. of Downloads: 15 | No. of Views: 198

An Overview of Openings in Concrete Deep Beams-A Comprehensive Analysis

Bilal Alhammud, Dr. Ayse Yeter Günal, Rajab Alkhatib.

May 2024 - Vol 12, Issue 3
Properties of Concrete on Adding Polypropylene Fibre and Polyvinyl Chloride Fibre

Aaqib Bashir, Brahmjeet Singh.

January 2024 - Vol 12, Issue 1
Revitalizing Infrastructure: Assessing Concrete Jacketing for Reinforced Concrete Column Rehabilitation

Samsul Abdul Rahman Sidik Hasibuan.

January 2024 - Vol 12, Issue 1

IJIRCST

An Experimental Study on Quarry Dust as Partial Replacement for Sand in Concrete

Citations

Download Full Paper PDF

Total View 198

Total Download 15