An Examination the Use of Sugarcane Bagasse Ash as Cement Partial Substitutes in Concrete

Abhishek Kumar; Er. Madhu Bala; Er. Harish Sharma

Abstract

The strength and shrinkage of concrete that is combined with sugarcane bagasse ash particles are influenced by the size of the particles, as analyzed in this research article. A higher amount of water is required when utilizing Sugarcane Bagasse Ash (ScBA) in concrete. The strength of the mixture created with fine ScBA can be comparable to or greater than that of standard concrete. The ScBA waste produced from sugarcane contracts substantially as a consequence of the presence of minute components within it. In this study, the researchers utilized a material known as Sugarcane Bagasse Ash (ScBA) to substitute cement in concrete. The experiment involved testing the effectiveness of ScBA (at different percentages: 0%, 5%, 10%, 15%, and 20%) in strengthening M20 concrete over a period of 28 days. They compared it to regular concrete. The extent to which it could resist pressure and strain without snapping was measured. The reason behind burning Sugarcane waste (ScBA) for fuel is its ability to produce significant amounts of heat. Cement can be supplemented with the remaining ash after it has been burnt.

Keywords

Compressive strength Concrete, Split Tensile Strength, Durability, Sugarcane Bagasse Ash, Workability.

References

R. Srinivasan, K. Sathiya (2010), “Experimental Study on Bagasse Ash in Concrete, ‘International Journal for Service Learning in Engineering, Vol. 5, No. 2, pp. 60-66, ISSN 1555-9033.
Arya B. Changela, Dr. Ramdevsinh Jhala, Chirag P. Kalariya, Keyur P. Hirpara (2015), “Rigid Dynamics Solution Methodology for 3-PSU Parallel Kinematic Manipulators, ‘International Journal of Innovative Research in Science, Engineering and Technology, Vol. 4, Issue 4, ISSN(Online): 2319 – 8753, ISSN (Print): 2347 – 6710.
Sirirat Janjaturaphan and Supaporn Wansom (2010), “Pozzolanic Activity of Industrial Sugarcane Bagasse Ash, ‘National Metal and Materials Technology Canter (MTEC), National Science and Technology Development Agency (NSTDA), 114, Tel.: 0-2564-6500 ext. 4042, Fax.: 564-6368.
Pragalbha Khare, Mohd. Afaque Khan, Neeti Mishra (2018), “Partial Replacement of Cement with Sugarcane Bagasse Ash in Concrete: A Review, ‘International Research Journal of Engineering and Technology (IRJET), e- ISSN: 2395-0056, p-ISSN: 2395-0072, Volume: 05 Issue: 04.
Prashant O Modania, M R Vyawahareb (2012), “Utilization of Bagasse Ash as a Partial Replacement of Fine Aggregate in Concrete, ‘Selection and peer-review under responsibility of Institute of Technology, Nirma University, Ahmedabad.doi: 10.1016/j.proeng.2013.01.007.
A. Bahurudeen, Deepak Kanraj, V. Gokul Dev, Manu Santhanam (2015), “Performance evaluation of sugarcane bagasse ash blended cement in concrete, ‘Journal homepage: www.elsevier.com/locate/cemconcomp.
Almir Sales, Sofia Araújo Lima (2010), “Use of Brazilian sugarcane bagasse ash in concrete as sand replacement, ‘Journal homepage: www.elsevier.com/locate/cemconcomp.
Muhammad Jahanzaib Khalil, Muhammad Aslam, Sajjad Ahmad (2020), “Utilization of sugarcane bagasse ash as cement replacement for the production of sustainable concrete – A review, ‘‘Journal homepage: www.elsevier.com/locate/cemconcomp.
Sajjad Ali Mangi, Jamaluddin N, Wan Ibrahim M H, Abd Halid Abdullah, A S M Abdul Awal, Samiullah Sohu and Nizakat Ali (2017), “Utilization of sugarcane bagasse ash in concrete as partial replacement of cement, ‘IOP Conf. Series: Materials Science and Engineering 1234567890271 (2017) 012001 doi:10.1088/1757- 899X/271/1/012001.
Waqas Ahmad, Ayaz Ahmad, Krzysztof Adam Ostrowski, Fahid Aslam, Panuwat Joyklad, Paulina Zajdel (2021), “Sustainable approach of using sugarcane bagasse ash in cement-based composites: A systematic review, ‘Journal homepage: www.elsevier.com/locate/cemconcomp.
Jose da Silva Andrade Neto, Mavisson Júlio Santos de França, Nilson Santana de Amorim Júnior, Daniel Véras Ribeiro (2021), “Effects of adding sugarcane bagasse ash on the properties and durability of concrete, ‘Journal homepage: www.elsevier.com/locate/cemconcomp.
T. S. Abdulkadir, d. O. Oyejobi, a. A. Lawal (2014), “Evaluation of Sugarcane Bagasse Ash as a Replacement for cement in concrete works, ‘ACTA TEHNICA CORVINIENSIS – Bulletin of Engineering Tome VII, ISSN: 2067 – 3809.
J Paya, J Monzo, MV Borrachero, L D?az-Pinzon and LM Ordonez (2001), “Sugar-cane bagasse ash (SCBA): studies on its properties for reusing in concrete production, ‘Paper presented at the PROGRES Workshop: Novel Products from Combustion Residues, 6–8 June 2001, Morella, Spain.
T. Murugesan, R. Vidjeapriya, A. Bahurudeen (2020), “Sugarcane Bagasse Ash-Blended Concrete for Effective Resource Utilization Between Sugar and Construction Industries, ‘https://doi.org/10.1007/s12355-020- 00794-2.
P.V. Andreao, A.R. Suleiman, G.C. Cordeiro, M.L. Nehdi (2019), “Sustainable Use of Sugarcane Bagasse Ash in Cement Based Materials, ‘doi 10.1680/jgrma.18.00016.
K. Lakshmi Priya, R. Ragupathy (2017), “Effect of Sugarcane Bagasse Ash on Strength Properties of Concrete, ‘International Journal of Research in Engineering and Technology eISSN: 2319-1163 | pISSN: 2321- 7308.
A. Rajasekar, K. Arunachalam, M. Kottaisamy, V. Saraswathy (2018), “Durability characteristics of Ultra High Strength Concrete with treated sugarcane bagasse ash, ‘‘Journal homepage: www.elsevier.com/locate/cemconcomp.
Nasir Shafiq, Asma Abd Elhameed Hussein, Muhd Fadhil Nuruddin, Hashem Al Mattarneh (2016), “Effects of sugarcane bagasse ash on the properties of concrete, ‘http://dx.doi.org/10.1680/jensu.15.00014.
Jeevanjot Singh, Dr. Sandeep Chandel (June2023), “An Examination and Investigation Compressive Strength the Use of Waste Paper Sludge Ash and Rice Husk Ash as Cement Substitutes in Concrete, ‘International Journal of Innovative Research in Engineering and Management (IJIREM), ISSN(Online): 2350-0557, Volume-10, Issue- 3, https://doi.org/10.55524/ijirem.2023.10.3.11. (www.ijirem.org.).

Cites this article as

A. Kumar, E. M. Bala, E. H. Sharma, "An Examination the Use of Sugarcane Bagasse Ash as Cement Partial Substitutes in Concrete", International Journal of Innovative Research in Computer Science and Technology (IJIRCST), Vol-11, no.4, pp.67-73, 2023. Available from: https://doi.org/10.55524/ijircst.2023.11.4.13

Corresponding Author

Abhishek Kumar

M.Tech Scholar, Department of Civil Engineering, Sant Baba Bhag Singh University, Khiala, Jalandhar, India

Download Full Paper

Download PDF

No. of Downloads: 34 | No. of Views: 672

An Overview of Openings in Concrete Deep Beams-A Comprehensive Analysis

Bilal Alhammud, Dr. Ayse Yeter Günal, Rajab Alkhatib.

May 2024 - Vol 12, Issue 3
Properties of Concrete on Adding Polypropylene Fibre and Polyvinyl Chloride Fibre

Aaqib Bashir, Brahmjeet Singh.

January 2024 - Vol 12, Issue 1
Revitalizing Infrastructure: Assessing Concrete Jacketing for Reinforced Concrete Column Rehabilitation

Samsul Abdul Rahman Sidik Hasibuan.

January 2024 - Vol 12, Issue 1

IJIRCST

An Examination the Use of Sugarcane Bagasse Ash as Cement Partial Substitutes in Concrete

Citations

Download Full Paper PDF

Total View 672

Total Download 34